Connecting AnMBR and SOFC for Blackwater Treatment and Energy Production: Influence of the AnMBR pH on the SOFC Operational Strategy

Connecting AnMBR and SOFC for Blackwater Treatment and Energy Production: Influence of the AnMBR pH on the SOFC Operational Strategy

Zha, Qinying (TU Delft Civil Engineering & Geosciences)

Lindeboom, R.E.F. (mentor)
Spanjers, H. (graduation committee)
Heijman, Sebastiaan (graduation committee)
van Lier, J.B. (graduation committee)
Aravind, P.V. (graduation committee)

Delft University of Technology

Delft University of Technology

Civil Engineering | Structural Engineering

2023-08-24

Driven by the increasing demand for waste reduction and green energy production, an integrated system which combines an anaerobic membrane bioreactor (AnMBR) and a solid oxide fuel cell (SOFC) was proposed in this research project for blackwater treatment and energy production. The potentials of using an AnMBR for wastewater treatment and biogas production, and the feasibilities of producing energy from biogas with a SOFC have been investigated by many researchers. Although, combining the two equipment might raise new challenges and opportunities. The AnMBR pH has direct impacts on the biogas composition, which would subsequently affect the SOFC operational strategy. Therefore, this research project focused on the influence of the AnMBR pH on the SOFC operational strategy, which would provide insights for connecting AnMBR and SOFC. The AnMBR pH was controlled around 8 initially, and then reduced to 7. The composition of the biogas produced under each pH condition was analyzed before the biogas was conditioned for the SOFC operation. Biochar adsorption and CO2 addition were applied for biogas conditioning. pH 8 was favorable for biochar adsorption, whereas pH 7 was favorable for CO2 addition. The aim of biochar adsorption was to ensure that the H2S concentration remaining in the biogas after adsorption was less than 0.5 ppm, so that sulfur poisoning could be avoided at the anode of SOFC. A biochar column (BC) was attached to the AnMBR for the adsorption of sulfur compounds in the biogas. The BC was packed with biochar made of cow manure. The adsorption capacity of the biochar was measured to determine the amount of biochar required in the BC. After biochar adsorption, the ratio between CH4 and CO2 was balanced by adding CO2 to the biogas, to reduce the risk of carbon deposition at the anode of SOFC. The exhaust gas discharged by the SOFC could also be recycled as an alternative to CO2 addition. The performance of the SOFC system using the conditioned biogas as the fuel was assessed based on electric power output and fuel utilization efficiency. Based on the results of biogas production, conditioning, and utilization, the influence of the AnMBR pH on the SOFC operational strategy was analyzed. Furthermore, the potentials and the limitations of connecting AnMBR and SOFC were discussed.

anaerobic membrane bioreactor (AnMBR)
solid oxide fuel cell (SOFC)
biochar
biogas
pH
blackwater treatment
energy recovery

http://resolver.tudelft.nl/uuid:8801278f-11c2-4be4-b4b3-a3078b69afce

Student theses

master thesis

© 2023 Qinying Zha