Excess sewage sludge in wastewater treatment plants (WWTPs) is regarded the key energy source for achieving energy neutral WWTPs. The anaerobic digestion process transforms sludge-organic matter into methane, which subsequently can be used for heat and electricity production. Conventional anaerobic digesters (ADs) have been used for sludge treatment for many decades, requiring high energy and providing poor effluent quality. Anaerobic membrane bioreactor (AnMBR) technology exhibits a promising option for treatment of high solids concentration streams including sludge. AnMBRs result in an increase in digestion efficiency and enhancement in effluent quality at small footprints. AnMBRs have the potential to reduce capital and operational costs, and produce more energy in comparison to conventional ADs. Thus, energy neutral or positive operation can be achieved with AnMBRs. Besides, nutrient recovery or direct use of permeate will become more feasible in AnMBRs compared to use of sludge supernatant in ADs. However, membrane fouling can limit the feasibility of AnMBRs for sludge treatment, which requires further research. This review paper critically evaluates the current status of AnMBR technology for municipal sludge treatment discussing the effect of different factors on treatment and membrane filtration performances. Furthermore, future research opportunities to enhance applicability of this technology are addressed. (Figure presented.).@en

Whey, produced in large quantities during cheese production, is a rapidly fermentable high strength wastewater characterized by a high biodegradability and low alkalinity. In this study, a lab-scale cross-flow anaerobic membrane bioreactor was used to address the commonly experienced difficulties such as unstable reactor performance and unexpected biomass losses when treating whey wastewater with conventional anaerobic reactors. The anaerobic membrane bioreactor provided a stable treatment performance, i.e. more than 90% chemical oxygen demand removal, and moderate membrane fluxes between 8 and 11 L m−2 h−1 could be obtained, applying a low cross-flow velocity of about 0.5 m s−1. Short term critical flux tests revealed that higher fluxes up to 36 L m−2 h−1 are possible at elevated cross-flow velocities and/or reduced mixed liquor suspended solids concentrations. Sludge filterability indicated by capillary suction time and specific resistance to filtration deteriorated throughout the study. Chemical cleaning efficiency gradually decreased, indicating irreversible membrane fouling during long term operation.@en

Energy-rich sludge can be obtained from primary clarifiers preceding biological reactors. Alternatively, the incoming wastewater can be sent to a very-high-loaded activated sludge system, i.e., a so-called A-stage. However, the effects of applying an A-stage instead of a primary clarifier, on the subsequent sludge digestion for long-term operation is still unknown. In this study, biogas production and permeate quality, and filterability characteristics were investigated in a lab-scale anaerobic membrane bioreactor for primary sludge and A-stage sludge (A-sludge) treatment. A higher specific methane yield was obtained from digestion of A-sludge compared to primary sludge. Similarly, specific methanogenic activity was higher when the anaerobic membrane bioreactor was fed with A-sludge compared to primary sludge. Plant-wide mass balance analysis indicated that about 35% of the organic matter in wastewater was recovered as methane by including an A-stage, compared to about 20% with a primary clarifier.@en