Heat transfer in the stagnation point area of a heated cylinder is investigated using Direct Numerical Simulation (DNS). The heated cylinder is subjected to the turbulent wake of a smaller cylinder placed upstream. Two Reynolds numbers based on the diameter of the heated cylinder of 13,200 and 48,000 are chosen. In accordance with correlations in the literature, an increase in heat transfer compared to fully laminar flow is found for all angles along the front circumferential area of the heated cylinder. However, due to the presence of the wake, the maximum increase is shifted away from the centerline. The characteristic turbulence level and Nusselt number in the present study are an order of magnitude higher than those reported in previous simulations. The DNS results obtained, are in good agreement with an existing experimental correlation. Finally, relevant flow structures and instantaneous temperature fields are visualized.@en

Immersed gratings offer several advantages over conventional gratings: more compact spectrograph designs, and by using standard semiconductor industry techniques, higher diffraction-efficiency and lower stray-light can be achieved. We present the optical tests of the silicon immersed grating demonstrator for the Mid-infrared E-ELT Imager and Spectrograph, METIS. We detail the interferometric tests that were done to measure the wavefront-error and present the results of the throughput and stray-light measurements. We also elaborate on the challenges encountered and lessons learned during the immersed grating demonstrator test campaign that helped us to improve the fabrication processes of the grating patterning on the wafer. @en

From experimental studies it is well established that free-stream and wake-induced turbulence can increase the heat transfer on curved surfaces such as turbine blades or cylinders even if the mean flow matches corresponding laminar velocity profiles. Here, preliminary results of an investigation using (embedded) Direct Numerical Simulation (DNS) are reported that aim at identifying the responsible physical mechanisms for this phenomenon. The setup follows an existing experiment where a heated cylinder is subjected to the turbulent wake of a smaller cylinder placed upstream. The Reynolds number based on the diameter of the heated cylinder is Re = 48, 000. A key parameter identified in an experimental correlation is the characteristic turbulence level Tua that includes a dependency on Re and the mean flow acceleration. For the present study, Tua is an order of magnitude higher than those reported in any previous DNS. The obtained Nusselt number is in good agreement with the experimental correlation. More and better resolved data is currently produced for further analysis.@en