The study investigated the effects of long-chain fatty acids (LCFA) on anaerobic sludge treating lipid-rich wastewater. It involved batch experiments with three sludge samples: two acclimated to lipids and one non-acclimated. The experiments aimed to observe the degradation of LCFA, specifically oleate and palmitate, by dosing them at concentrations ranging from 50 to 600 mg/L. Measurements of the cumulative methane production and the LCFA concentration, quantified as fat, oil, and grease (FOG) were performed. To ensure the sludge was free from other biodegradable substrates, part of the samples was pre-incubated without feed. The tests were conducted with both pre-incubated and non-incubated inoculum sludge. The findings revealed that oleate was degraded more efficiently than palmitate across all sludge samples, with a greater conversion rate to methane. Sludge samples acclimated to lipids showed a superior capacity to degrade LCFA compared to non-acclimated ones. It was noted that at concentrations above 400 mg/L, the conversion of LCFAs to intermediate compounds was inhibited, although this did not affect the subsequent methane production. The study concludes with a recommendation for sludge adaptation strategies to boost the efficiency of anaerobic wastewater treatment systems dealing with lipid-rich waste. The presence of LCFA-degrading bacteria families like Kosmotogaceae, Petrotogaceae, and Synergistaceae in the acclimated sludge samples underscores the adaptation and potential for improved degradation performance.@en

In this study, the impact of applied solids retention time (SRT) on the biological performance of an anaerobic membrane bioreactor (AnMBR) treating synthetic dairy wastewater with high lipid content was assessed. Two side-stream AnMBR systems were operated at an SRT of 20 and 40 days (R20 and R40, respectively), equipped with an inside-out tubular membrane operated in cross-flow mode under full-scale operational conditions, i.e. crossflow velocity, transmembrane pressure, membrane flux. Successful operation was achieved and removal efficiencies of both reactors were up to 99% applying an organic loading rate (OLR) of 4.7 g COD L−1 d−1. No precipitation of lipids was observed throughout the operational period, keeping the lipids available for the anaerobic degradation. Long chain fatty acid (LCFA) accumulation was very modest and amounted 148 and 115 mg LCFA-COD per gram of volatile suspended solids (VSS) for R20 and R40, respectively. At an SRT of 40 days, a slightly better biological conversion was obtained. Periodically performed specific methanogenic activity (SMA) tests showed stabilization of the SMA for R40 sludge, whereas for R20 sludge the SMA continued to decrease. This study revealed a more stable reactor performance operating the AnMBR at an SRT of 40 days compared to 20 days.@en

This study evaluated the effects of sludge retention time (SRT) on the membrane filtration performance of an anaerobic membrane bioreactor (AnMBR) fed lipid-rich synthetic dairy wastewater. The membrane filtration performance was evaluated in two AnMBR systems operated at two different SRTs, i.e., 20 and 40 days. For the AnMBR operated at 40 days, SRT exhibited worse membrane filtration performance characterized by operational transmembrane pressures (TMP) exceeding the maximum allowed value and high total resistances to filtration (Rtotal). The sludge in the two reactors evaluated at the different SRTs showed similar sludge filterability properties. However, the sludge in the reactor operated at 40 days SRT was characterized by exhibiting the highest concentrations of: (i) total suspended solids (TSS), (ii) small-sized particles, (iii) extracellular polymeric substances (EPS), (iv) soluble microbial products (SMP), (v) fats, oils and grease (FOG), and (vi) long-chain fatty acids (LCFA). The cake layer resistance was the major contributor to the overall resistance to filtration. The high TSS concentration observed in the AnMBR systems apparently contributed to a less permeable cake layer introducing a negative effect on the membrane filtration performance.@en

Eutrophication episodes have been recently observed in the Santa Lucia river basin (SLRB) in Uruguay, the main drinking water source for approximately 60% of the Uruguayan population. The local environmental authorities have been strengthening the discharge standards for that particular river basin. There are several industries currently discharging their wastewater directly into the SLRB; some of these industries are required to upgrade their current wastewater treatment systems to comply with the new regulations. This study evaluated the performance of a membrane bioreactor (MBR) on dairy wastewater as a potential treatment technology for fulfilling the new discharge standards. A pilot MBR was placed at the dairy industry wastewater treatment system at two different locations: (i) receiving the wastewater from the industrial process after passing through a grease removal pond (high load stream); and (ii) receiving the wastewater after passing through the grease removal pond and an anaerobic pond (low load stream). The pilot MBR was operated at the following conditions for approximately four months: total sludge retention, hydraulic retention time (HRT) of 25 h, an average influent flow rate of 1.3 m3 day-1, and at two different average chemical oxygen demand (COD) influent concentrations: 1300 mg L-1 (high load stream) and 385 mg L-1 (low load stream). The average reported removal efficiencies on COD, biological oxygen demand (BOD), and ammonium (NH4-N) were 94.1, 98.1, and 99.6%, respectively. In addition, it was observed that for a COD/N ratio above 10, total nitrogen (TN) and total phosphorous (TP) were well removed with average removal efficiencies of 93.1 and 91.0%, respectively. The MBR effluent met the new Uruguayan standards for discharging into the SLRB, and it can be further considered for water reuse at the industrial process. Moreover, a financial feasibility study was carried out for the implementation of a full scale MBR at the existing dairy facility. The results of the feasibility study suggested to accept the investment for the implementation of the MBR technology at the dairy industry. The results of the feasibility analysis considered the high impact of penalties and fines imposed by the local government to the industry when not complying with the effluent discharge standards, as well as the critical situation regarding eutrophication of the SLRB while being the most important source for drinking water in Uruguay.@en