Non-oxidative dehydroaromatization of methane (MDA) is a promising catalytic process for direct valorization of natural gas to liquid hydrocarbons. The application of this reaction in practical technology is hindered by a lack of understanding about the mechanism and nature of the active sites in benchmark zeolite-based Mo/ZSM-5 catalysts, which precludes the solution of problems such as rapid catalyst deactivation. By applying spectroscopy and microscopy, it is shown that the active centers in Mo/ZSM-5 are partially reduced single-atom Mo sites stabilized by the zeolite framework. By combining a pulse reaction technique with isotope labeling of methane, MDA is shown to be governed by a hydrocarbon pool mechanism in which benzene is derived from secondary reactions of confined polyaromatic carbon species with the initial products of methane activation.@en

Liu et al. recently reported their results on coconversion of methane and methanol at 973 K over a typical methane dehydroaromatization (MDA) catalysts, Mo/HZSM-5.1 In this work, the authors claimed that adding a small amount of methanol to a methane feed led to more than two times higher methane conversion, substantially higher xylene and toluene selectivities (i.e., combined ca. 80%, nearly an order of magnitude increase as compared to experiments without methanol), and improved catalyst stability to such an extent that no deactivation was observed during 60 h on stream. If reproducible, this result would be a significant achievement, because formation of coke in the MDA reaction has been considered inevitable hitherto. To support their experimental data, Liu et al. carried out a thermodynamic analysis, whose results were in good agreement with their experimental findings.@en