Magnetic resonance imaging (MRI) experiments have been performed in conjunction with direct numerical simulations (DNS) to study neutrally buoyant particle-laden pipe flows. The flows are characterized by the suspension liquid Reynolds number (Res), based on the bulk liquid velocity and suspension viscosity obtained from Eilers' correlation, the bulk solid volume fraction (φb), and the particle-to-pipe diameter ratio (d/D). Six different cases have been studied, each with a unique combination of Res and φ, while d/D is kept constant at 0.058. The selected cases ensure that the comparison is performed across different flow regimes, each exhibiting characteristic behavior. In general, an excellent agreement is found between experiment and simulation for the average liquid velocity and solid volume fraction profiles. Root-mean-square errors as low as 1.7% and 5.3% are found for the velocity and volume fraction profiles, respectively. This study presents accurate and quantitative velocity and volume fraction profiles of semidilute up to dense suspension flows using both experimental and numerical methods. Three different flow regimes are identified, based on the experimental and numerical solid volume fraction profiles. These profiles explain observations in the drag change. For low bulk solid volume fractions a drag increase (with respect to an equal Res single-phase case) is observed. For moderate volume fraction distributions the drag is found to decrease, due to particle accumulation at the pipe center. For high volume fractions the drag is found to decrease further. For solid volume fractions of 0.4 a drag reduction higher than 25% is found. This drag reduction is linked to the strong viscosity gradient in the radial direction, where the relatively low viscosity near the pipe wall acts as a lubrication layer between the pipe wall and the dense core.@en

Using magnetic resonance imaging we are able to obtain average velocity and volume fraction profiles in a pipe flow with a neutrally buoyant suspension. In this experimental work, the effect of increasing Reynolds number and particle volume fraction on shear-induced migration is studied. For increasing bulk volume fraction, the initially nearly homogeneous suspension gradually changes to a strongly non-homogeneous suspension. This is observed for all studied Reynolds numbers. In contrast to the majority of previous (MRI) studies, experiments are also performed for suspension Reynolds numbers of approximately 5000 in order to study inertial effects on shear-induced migration.@en