Due to climate change and increasing droughts, wastewater treatment and water reuse are gaining importance. Yet, the state-of-the-art bubble-aerated membrane bioreactor (BA-MBR) faces competitiveness challenges due to its high energy use and maintenance requirements, especially at small scale. This study investigates a novel membrane-aerated MBR (MA-MBR) that integrates membrane aeration and filtration to reduce energy consumption and system footprint, enabling resource-efficient non-potable reuse. The MA-MBR treated greywater for domestic reuse and achieved stable chemical oxygen demand (COD) removal efficiencies up to 95 % at high loading rates (up to 4 g L⁻¹ d⁻¹) and produced effluent with biological oxygen demand (BOD₅) values below 5 mg L⁻¹, meeting stringent reuse standards. Biomass dynamics revealed two distinct forms: biofilm on aeration membranes and flocs in suspension. Coarse bubble scouring facilitated biofilm detachment, enabling solid retention time (SRT) control. Oxidation-reduction potential (ORP) was linked to the biomass detachment efficiency, with negative ORP reducing mixed liquor suspended solids (MLSS) after scouring 5–10 times compared to operation at positive ORP. Reattachment of flocs reduced MLSS levels by 90 % within 60 min. A 25 % lower transmembrane pressure (TMP) in the MA-MBR compared to the BA-MBR after 72 h indicated lower fouling rates. Microbial communities were distinctly different between biofilm and flocs, especially under negative ORP conditions. These findings suggest the MA-MBR as low-footprint, low-fouling alternative for carbon removal from wastewaters with relatively high COD/N-ratios, and may improve resource efficiency for non-potable water reuse, for instance in decentralized source-separation applications.

Long-term human Space missions will rely on regenerative life support as resupply of water, oxygen and food comes with constraints. The International Space Station (ISS) relies on an evaporation/condensation system to recover 74–85% of the water in urine, yet suffers from repetitive scaling and biofouling while employing hazardous chemicals. In this study, an alternative non-sanitary five-stage treatment train for one “astronaut” was integrated through a sophisticated monitoring and control system. This so-called Water Treatment Unit Breadboard (WTUB) successfully treated urine (1.2-L-d⁻¹) with crystallisation, COD-removal, ammonification, nitrification and electrodialysis, before it was mixed with shower water (3.4-L-d⁻¹). Subsequently, ceramic nanofiltration and single-pass flat-sheet RO were used. A four-months proof-of-concept period yielded: (i) chemical water quality meeting the hygienic standards of the European Space Agency, (ii) a 87-±-5% permeate recovery with an estimated theoretical primary energy requirement of 0.2-kWh_p-L⁻¹, (iii) reduced scaling potential without anti-scalant addition and (iv) and a significant biological reduction in biofouling potential resulted in stable but biofouling-limited RO permeability of 0.5 L-m⁻²-h⁻¹-bar⁻¹. Estimated mass breakeven dates and a comparison with the ISS Water Recovery System for a hypothetical Mars transit mission show that WTUB is a promising biological membrane-based alternative to heat-based systems for manned Space missions.

Human urine is a valuable resource for nutrient recovery, given its high levels of nitrogen, phosphorus and potassium, but the compositional complexity of urine presents a challenge for an energy-efficient concentration and refinery of nutrients. In this study, a pilot installation combining precipitation, nitrification and electrodialysis (ED), designed for one person equivalent (1.2 L_urine d⁻¹), was continuously operated for ∼7 months. First, NaOH addition yielded calcium and magnesium precipitation, preventing scaling in ED. Second, a moving bed biofilm reactor oxidized organics, preventing downstream biofouling, and yielded complete nitrification on diluted urine (20–40%, i.e. dilution factors 5 and 2.5) at an average loading rate of 215 mg N L⁻¹ d⁻¹. Batch tests demonstrated the halotolerance of the nitrifying community, with nitrification rates not affected up to an electrical conductivity of 40 mS cm⁻¹ and gradually decreasing, yet ongoing, activity up to 96 mS cm⁻¹ at 18% of the maximum rate. Next-generation 16S rRNA gene amplicon sequencing revealed that switching from a synthetic influent to real urine induced a profound shift in microbial community and that the AOB community was dominated by halophilic species closely related to Nitrosomonas aestuarii and Nitrosomonas marina. Third, nitrate, phosphate and potassium in the filtered (0.1 μm) bioreactor effluent were concentrated by factors 4.3, 2.6 and 4.6, respectively, with ED. Doubling the urine concentration from 20% to 40% further increased the ED recovery efficiency by ∼10%. Batch experiments at pH 6, 7 and 8 indicated a more efficient phosphate transport to the concentrate at pH 7. The newly proposed three-stage strategy opens up opportunities for energy- and chemical-efficient nutrient recovery from urine. Precipitation and nitrification enabled the long-term continuous operation of ED on fresh urine requiring minimal maintenance, which has, to the best of our knowledge, never been achieved before.

In order to sustain human life in an isolated environment, an efficient conversion of wasted nutrients to food might become mandatory. This is particularly the case for space missions where resupply from earth or in-situ resource utilization is not possible or desirable. A combination of different technologies is needed to allow full recycling of e.g. nitrogenous compounds in space. In this review, an overview is given of the different essential processes and technologies that enable closure of the nitrogen cycle in Bioregenerative Life Support Systems (BLSS). Firstly, a set of biological and physicochemical refinery stages ensures efficient conversion of waste products into the building blocks, followed by the production of food with a range of biological methods. For each technology, bottlenecks are identified. Furthermore, challenges and outlooks are presented at the integrated system level. Space adaptation and integration deserve key attention to enable the recovery of nitrogen for the production of nutritional food in space, but also in closed loop systems on earth.