Long-term consumption of groundwater containing elevated levels of arsenic (As) can have severe health consequences, including cancer. To effectively remove As, conventional treatment technologies require expensive chemical oxidants to oxidise neutral arsenite (As(III)) in groundwater to negatively charged arsenate (As(V)), which is more easily removed. Rapid sand filter beds used in conventional aeration-filtration to treat anaerobic groundwater can naturally oxidise As(III) through biological processes but require an additional step to remove the generated As(V), adding complexity and cost. This study introduces a novel approach where As(V), produced through biological As(III) oxidation in a sand filter, is effectively removed within the same filter by embedding and operating an iron electrocoagulation (FeEC) system inside the filter. Operating FeEC within the biological filter achieved higher As(III) removal (81 %) compared to operating FeEC in the filter supernatant (67 %). This performance was similar to an analogous embedded-FeEC system treating As(V)-contaminated water (85 %), confirming the benefits of incorporating FeEC in a biological bed for comparable As(III) and As(V) removal. However, operating FeEC in the sand matrix consumed more energy (14 Wh/m³) compared to FeEC operated in a water matrix (7 Wh/m³). The efficiency of As removal increased and energy requirements decreased in such embedded-FeEC systems by deep-bed infiltration of Fe(III)-precipitates, which can be controlled by adjusting flow rate and pH. This study is one of the first to demonstrate the feasibility of embedding FeEC systems in sand filters for groundwater arsenic removal. Such systems capitalise on biological As(III) oxidation in aeration-filtration, effectively eliminating As(V) within the same setup without the need for chemicals or major modifications.

Groundwater contaminated with arsenic (As) must be treated prior to drinking, as human exposure to As at toxic levels can cause various diseases including cancer. Conventional aeration-filtration applied to anaerobic arsenite (As(III)) contaminated groundwater can remove As(III) by co-oxidizing native iron (Fe(II)) and As(III) with oxygen (O₂). However, the As(III) removal efficiency of conventional aeration can be low, in part, because of incomplete As(III) oxidation to readily-sorbed arsenate (As(V)). In this work, we investigated a new approach to enhance As(III) co-removal with native Fe(II) by the anaerobic addition of hydrogen peroxide (H₂O₂) prior to aeration. Experiments were performed to co-oxidize Fe(II) and As(III) with H₂O₂ (anaerobically), O₂ (aerobically), and by sequentially adding of H₂O₂ and O₂. Aqueous As(III) and As(V) measurements after the reaction were coupled with solid-phase speciation by Fe and As K-edge X-ray absorption spectroscopy (XAS). We found that complete anaerobic oxidation of 100 µM Fe(II) with 100 µM H₂O₂ resulted in co-removal of 95% of 7 µM As(III) compared to 44% with 8.0-9.0 mg/L dissolved O₂. Furthermore, we found that with 100 µM Fe(II), the initial Fe(II):H₂O₂ ratio was a critical parameter to remove 7 µM As(III) to below the 10 µg/L (0.13 µM) WHO guideline, where ratios of 1:4 (mol:mol) Fe(II):H₂O₂ led to As(III) removal matching that of 7 µM As(V). The improved As(III) removal with H₂O₂ was found to occur partly because of the well-established enhanced efficiency of As(III) oxidation in Fe(II)+H₂O₂ systems relatively to Fe(II)+O₂ systems. However, the XAS results unambiguously demonstrated that a large factor in the improved As(III) removal was also due to a systematic decrease in crystallinity, and thus increase in specific surface area, of the generated Fe(III) (oxyhydr)oxides from lepidocrocite in the Fe(II)+O₂ system to poorly-ordered Fe(III) precipitates in the Fe(II)+H₂O₂ system. The combined roles of H₂O₂ (enhanced As(III) oxidation and structural modification) can be easily overlooked when only aqueous species are measured, but this dual impact must be considered for accurate predictions of As removal in groundwater treatment.

Arsenic (As) is a toxic element present in many (ground)water sources in the world. Most conventional As removal techniques require pre-oxidation of the neutral arsenite (As(III)) species to the negatively charged arsenate (As(V)) oxyanion to optimize As removal and minimize chemical use. In this work, a novel, continuous-flow As removal system was developed that combines biological As(III) oxidation by bacteria with Fe electrocoagulation (EC), an Fe(0)-based electrochemical technology that generates reactive Fe(III) precipitates to bind As. The bio-integrated FeEC system (bio-FeEC) showed effective oxidation and removal of 150 µg/L As(III), without the need of chemicals. To remove As to below the WHO guideline of 10 µg/L, 10 times lower charge dosage was required for the bio-FeEC system compared to conventional FeEC. This lower Fe dosage requirement reduced sludge production and energy consumption. The As(III) oxidizing biomass was found to consist of bacteria belonging to Comamonadaceae, Rhodobacteraceae and Acidovorax, which are capable of oxidizing As(III) and are common in drinking water biofilms. Characterization of the As-laden Fe solids by X-ray absorption spectroscopy indicated that both bio-FeEC and conventional FeEC produced solids consistent with a mixture of lepidocrocite and 2-line ferrihydrite. Arsenic bound to the solids was dominantly As(V), but a slightly higher fraction of As(V) was detected in the bio-FeEC solids compared to the conventional FeEC.