Polyhydroxyalkanoate (PHA) accumulating microbial enrichment was established on volatile fatty acids (VFAs) containing leachate derived from the organic fraction of municipal solid waste (OFMSW). The enrichment was based on a 12-h feast-famine batch cycle and an exchange ratio of 50% in which VFAs were completely consumed in less than 50 min during stable periods of operation. No pH control was applied in the system, and the pH went as high as 9 due to the presence of amongst others, ammonia [500 mg·L-1 total ammonia nitrogen (TAN) on average]. The degree of enrichment was evaluated with fluorescence in situ hybridization (FISH), and a yet unknown genus of large (3-5 μm diameter) beta-proteobacteria appeared dominant in the culture. A method for estimating the fraction of PHA accumulating active biomass in the total volatile suspended solids was established, and the results indicated an increase of this fraction from 25% to 56% after implementing two modifications in the operational protocol: (1) a pretreatment of the substrate removing virtually all settleable solids; and (2) a settling phase in the enrichment reactor after the feast phase, selectively removing nonsettleable solids and slowly degradable substrates. The PHA accumulation potential of the culture was 77±18 wt% PHA (n=3) after 3 h in batch accumulation experiments. The results suggest the potential feasibility of PHA production under conditions that were previously considered economically favorable but technically difficult.@en

In this study, the suitability of paper industry wastewater for production of polyhydroxyalkanoate (PHA) was investigated in a pilot reactor in an industrial setting. The pilot plant was designed as a three-step process comprising (1) anaerobic fermentation for maximization of the volatile fatty acid (VFA) concentration, (2) enrichment of PHA-producing biomass, and (3) accumulation for maximization of the PHA content of the biomass. After fermentation, the paper mill process water contained a VFA fraction of 78% on a chemical oxygen demand (COD) basis. The length of the feast phase in the enrichment process stabilized at 45 min±4 min after 18 days of operation. At the end of the feast phase all VFA was consumed and the PHA content of the volatile suspended solids (VSS) was 0.50 g PHA/g VSS±0.05 g PHA/g VSS. The acquired microbial community was dominated by Plasticicumulans acidivorans, a PHA-producing microorganism previously found to dominate VFA-fed laboratory reactors. The maximum PHA content achieved after accumulation was 0.70 to 0.80 g PHA/g VSS. An overall PHA yield of 34% on a COD basis was achieved. Improving the VFA fraction in the product spectrum of the fermentation and minimization of acid and base consumption for pH control were identified as major bottlenecks.@en