The anaerobic degradation of phenolic compounds presents substantial challenges due to their toxicity to methanogenic biomass and inherently low conversion rates. Recent studies indicate that nano-magnetite can stimulate direct interspecies electron transfer (DIET), potentially enhancing phenol conversion and methane production. This study employed two anaerobic membrane bioreactors (AnMBRs) to investigate phenol and p-cresol degradation under stepwise increasing loading rates, with complete retention of biomass in both reactors. While AnMBR-C served as a control, nano-magnetite was additionally supplemented to reactor AnMBR-M at a concentration of 40 mmol/L in Phase 1 and 20 mmol/L in Phase 2. Results demonstrated that AnMBR-M supplemented with 20 mmol/L nano-magnetite tolerated higher phenolic loading rates compared to AnMBR-C. In Phase 2, a higher total Fe concentration was observed in AnMBR-M, suggesting an enhanced electron transfer mechanism via dissimilatory iron reduction-oxidation cycle. Follow-up batch experiments revealed that magnetite-adapted biomass had more tolerance to phenol inhibition. A 16S-rRNA sequencing was conducted to characterize microbial communities within both reactors. Results suggested that DIET was stimulated in Phase 1, as shown by the enrichment of the electrogenic Pseudomonas and Methanolinea in AnMBR-M. However, the possibly stimulated DIET in Phase 1 could not alleviate the inhibition caused by excessive 40 mmol/L nano-magnetite dosage. Notably, there was no significant difference between the genera of AnMBR-C and AnMBR-M by the end of Phase 2. However, short-chain fatty acid degrader Mesotoga was more enriched in AnMBR-M. Moreover, species-level analysis showed that AnMBR-M had a sixfold higher relative abundance of Methanosaeta harundinacea compared to AnMBR-C.

Vinasse, a by-product of ethanol production, is generated at significant rates. While rich in nutrients such as calcium, magnesium, and potassium, its high solids, organic matter, acidity, and sulfate content pose challenges when disposed directly on soil, necessitating treatment. Anaerobic digestion is a viable solution, reducing organic pollution while recovering energy in the form of biogas, aligning with the biorefinery concept. Traditionally, sludge bed reactors and anaerobic contact reactors are utilized for vinasse processing, with sludge granulation being vital for treatment success. However, challenges such as sludge wash-out due to recalcitrant compounds, high solids concentration in the influent, low pH, salinity, and temperature hinder granule formation. Anaerobic membrane bioreactors (AnMBR) offer an alternative, simplifying treatment by integrating intensified pre- and post-treatment units. Due to complete sludge retention, AnMBRs achieve high COD removal efficiencies, yielding a suspended solids-free and largely disinfected effluent. Therefore, AnMBRs show promise for vinasse treatment, eliminating the need for sludge granulation and producing nutrient-rich effluent with minimal residual organics and suspended solids. In this study, an AnMBR equipped with an inside-out external crossflow ultrafiltration membrane was proposed for the treatment of vinasse. The AnMBR reached a COD removal efficiency of 95% ± 2.6% and produced 0.3 CH4 L. g COD removed -1 working at organic loading rates of 8 g COD. L-1 d-1 and membrane fluxes of 10 LMH. At organic loading rates of 10 g COD. L-1 d-1 and fluxes of 12 and 14 LMH, the COD removal efficiency decreased to 77% ± 11% and 73% ± 7.9%, respectively. The AnMBR technology represents an innovation for wastewater treatment, however, more research using the cross-flow configuration and different types of effluents is needed. Literature studies that address the treatment of sugar beet or sugarcane vinasse using AnMBR are still scarce. This study explored the potentials of AnMBR technology for vinasse treatment and contributes to the dissemination of this technology, opening new possibilities for vinasse processing.